冯伟忠,王琛,高云莉,赵甜甜
FENG Wei-zhong,WANG Chen,GAO Yun-li,ZHAO Tian-tian

• 1:西安工程大学材料工程学院
• 2:绍兴市柯桥区西纺纺织产业创新研究院

摘要(Abstract)：

为了改善聚乙烯醇(PVA)的耐水性及其对染料的吸附性能,以PVA为基体,纳米二氧化硅(SiO2)为分散相,酒石酸(TA)为交联剂,采用静电纺丝法制备了PVA/SiO2/TA纳米纤维膜,然后通过高温热处理得到耐水性交联纳米纤维膜。通过扫描电镜、傅里叶红外光谱、差热分析等手段表征了纤维形貌、化学组成及其热稳定性,并测试了纤维的拉伸性能、抗水解性能和吸附性能。结果表明:当SiO2质量分数为4%,TA质量分数为35%时,交联纳米纤维膜的拉伸性能较纯PVA纳米纤维膜的拉伸性能提高了4.1倍,溶胀度降低至2.16,质量损失率为3.4%,对亚甲基蓝(MB)的吸附率可达82%。
In order to improve the water resistance of polyvinyl alcohol and its ability to absorb dyes, using polyvinyl alcohol(PVA) as the matrix, nano silica(SiO2) as the dispersed phase, tartaric acid(TA) as the crosslinking agent, and the PVA/SiO2/TA nanofiber membrane is prepared by electrostatic spinning method,and then the water-resistant crosslinked nanofiber membrane is obtained through high temperature heat treatment. The fiber morphology, chemical composition and thermal stability were characterized by scanning electron microscopy. Fourier infrared spectroscopy, thermogravimetric and other means, and the mechanical properties, hydrolysis resistance and adsorption of the fibers were tested. The results show that when the SiO2 content is 4% and the tartaric acid content is 35%, the mechanical properties of the crosslinked nanofiber membrane are 4.1 times higher than that of the pure PVA nanofiber membrane, the swelling degree is reduced to 2.16, and the mass loss rate is 3.4%, the adsorption rate of methylene blue(MB) can reach 82%.

关键词(KeyWords)： 静电纺丝;二氧化硅;聚乙烯醇;抗水解性;吸附性能
electrospinning;silica;polyvinyl alcohol;hydrolysis resistance;adsorption performance

Abstract:

Keywords:

基金项目(Foundation): 中国纺织工业联合会科技指导项目(2018059);; 绍兴市柯桥区西纺纺织产业创新研究院产学研协同创新项目(19KQYB21);; 中纺联科技指导性项目(2020050)

作者(Author): 冯伟忠,王琛,高云莉,赵甜甜
FENG Wei-zhong,WANG Chen,GAO Yun-li,ZHAO Tian-tian

DOI: 10.16090/j.cnki.hcxw.2020.11.007

参考文献(References)：

• [1]李林刚,李刚.电纺Al2O3纳米纤维毡的制备及染料吸附脱色性能研究[J].材料导报,2020(18):1-14.
• [2]钱怡帆,周堂,张礼颖,等.聚丙烯腈/醋酸纤维素/Ti O2复合纳米纤维膜的制备及其光催化降解性能[J].纺织学报,2020,41(5):8-14.
• [3]LOU T,YAN X,WANG X.Chitosan coated polyacrylonitrile nanofibrous mat for dye adsorption[J].International Journal of Biological Macromolecules,2019,135:919-925.
• [4]苏宪章,高雯,韩丽艳,等.应用于污水处理领域聚乙烯醇膜材料的交联改性研究[J].绿色环保建材,2019(4):1-4.
• [5]ABDEL-HADY E E,MOHAMED H F M,ABDEL-HAMED M O,et al.Physical and electrochemical properties of PVA/Ti O2nanocomposite membrane[J].Advances in Polymer Technology,2018,37(8):3842-3853.
• [6]鄢小虎,潘婵,罗祝北,等.甲苯二异氰酸酯交联聚乙烯醇和羟乙基纤维素乳胶[J].中国胶粘剂,2017,26(7):40-44.
• [7]孙俊芬,顾亚峰,陈龙.环氧氯丙烷交联聚乙烯醇膜的制备与性能[J].东华大学学报(自然科学版),2019,45(1):23-28.
• [8]黄静,赵琦,卓坚锐,等.交联PVA/Si O2复合膜的制备及性能[J].塑料,2010,39(1):7-8,41.
• [9]GIL-CASTELL O,GALINDO-ALFARO D,SáNCHEZ-BALLESTERS,et al.Crosslinked sulfonated poly (vinyl alcohol)/graphene oxide electrospun nanofibers as polyelectrolytes[J].Nanomaterials,2019,9(3):397.
• [10]HOU C,JIAO T,XING R,et al.Preparation of Ti O2nanoparticles modified electrospun nanocomposite membranes toward efficient dye degradation for wastewater treatment[J].Journal of the Taiwan Institute of Chemical Engineers,2017,78:118-126.
• [11]DO NASCIMENTO F C,DE AGUIAR L C V,COSTA L A T,et al.Formulation and characterization of crosslinked polyvinyl alcohol (PVA) membranes:effectsofthecrosslinkingagents[J].Polymer Bulletin,2020:1-13.
• [12]颜琨,王琛,王亮,等.静电纺PAN/Si O2纳米纤维膜的制备及其过滤性能[J].西安工程大学学报,2020,34(1):20-27.
• [13]黄伟伟.气电纺Si O2/PTFE纳米纤维防水透湿膜制备及抗污性能研究[D].天津:天津工业大学,2018.
• [14]SONKER A K,VERMA V.Influence of crosslinking methods toward poly(vinyl alcohol) properties:Microwave irradiation and conventional heating[J].Journal of Applied Polymer Science,2017,135(14):1-8.
• [15]夏书会.静电纺丝法制备聚乙烯醇/二氧化硅复合纤维与性能研究[D].徐州:中国矿业大学,2018.
• [16]YOON J Y,ZHANG H,KIM Y K,et al.A high-strength polyvinyl alcohol hydrogel membrane crosslinked by sulfosuccinic acid for strontium removal via filtration[J].Journal of Environmental Chemical Engineering,2019,7(1):102824.
• [17]SONKER A K,RATHORE K,TEOTIA A K,et al.Rapid synthesis of high strength cellulose-poly(vinyl alcohol)(PVA) biocompatible composite films via microwave crosslinking[J].Journal of Applied Polymer Science,2019,136(17):1-9.
• [18]MEI Y,RUNJUN S,YAN F,et al.Preparation,characterization and kinetics study of chitosan/PVA electrospun nanofiber membranes for the adsorption of dye from water[J].Journal of Polymer Engineering,2019,39(5):459-471.